Vulcan-Hart STEAMER C24EO3 Bedienungsanleitung

This Manual is prepared for the use of trained Vulcan ServiceTechnicians and should not be used by those not properly qualified.This manual is not int

C24EO SERIES STEAMERS - REMOVAL AND REPLACEMENT OF PARTSDOORRemoval1. Close door.2. Remove left SIDE PANEL.3. Remove nuts from upper hinge located ins

C24EO SERIES STEAMERS - REMOVAL AND REPLACEMENT OF PARTSHandle Installation1. Apply Lubriplate 630AA around slots of outerdoor housing where step spac

C24EO SERIES STEAMERS - REMOVAL AND REPLACEMENT OF PARTSAssembly1. Apply Lubriplate 630AA to sides of slidingbracket.2. Insert spring pin into bottom

C24EO SERIES STEAMER - SERVICE PROCEDURES AND ADJUSTMENTSSERVICE PROCEDURES AND ADJUSTMENTSDOOR LATCH ADJUSTMENTOpening a Jammed Door Should the steam

C24EO SERIES STEAMER - SERVICE PROCEDURES AND ADJUSTMENTSHEATING ELEMENT TESTThe heating element assembly contains elementsmolded into a cast aluminum

C24EO SERIES STEAMER - SERVICE PROCEDURES AND ADJUSTMENTSTEMPERATURE CONTROLCALIBRATIONTo set the temperature control for optimum steameroperation, th

C24EO SERIES STEAMER - ELECTRICAL OPERATIONELECTRICAL OPERATIONCOMPONENT FUNCTIONBuzzer ... Creates audible signal when t

C24EO SERIES STEAMER - ELECTRICAL OPERATIONCOMPONENT LOCATIONCONTROL PANEL COMPONENTSFRONT PANEL COMPONENTSF25386 (June 2010)Page 17 of 24

C24EO SERIES STEAMER - ELECTRICAL OPERATIONSEQUENCE OF OPERATIONSchematic diagram AI2851 will be used to explainthe electrical sequence of operation.T

C24EO SERIES STEAMER - ELECTRICAL OPERATION8. Turn cook timer off.A. Timer contacts 11 & 14 open, buzzer is de-energized.B. Steamer reverts to hol

C24EO SERIES STEAMERSTABLE OF CONTENTSGENERAL ... 3Installation, Operatio

C24EO SERIES STEAMER - ELECTRICAL OPERATIONSCHEMATIC DIAGRAMF25386 (June 2010) Page 20 of 24

C24EO SERIES STEAMER - ELECTRICAL OPERATIONWIRING DIAGRAMS - HEATINGELEMENTS C24EO3 - 208V/240VF25386 (June 2010)Page 21 of 24

C24EO SERIES STEAMER - ELECTRICAL OPERATIONC24EO5 - 208V/240VF25386 (June 2010) Page 22 of 24

C24EO SERIES STEAMER - ELECTRICAL OPERATIONC24EO5 - 480VF25386 (June 2010)Page 23 of 24

C24EO SERIES STEAMER - TROUBLESHOOTINGTROUBLESHOOTINGSYMPTOM POSSIBLE CAUSESCompartment leaks water around door. 1. Steamer not level.2. Steamer overf

C24EO SERIES STEAMERS - GENERALGENERALINSTALLATION, OPERATIONAND CLEANINGRefer to the Installation & Operation Manual forspecific instructions.INT

C24EO SERIES STEAMERS - GENERALTOOLSStandard! Standard set of hand tools! Clear silicone sealant! VOM with an AC current tester (any qualityVOM with a

C24EO SERIES STEAMERS - REMOVAL AND REPLACEMENT OF PARTSREMOVAL AND REPLACEMENT OF PARTSCOVERS AND PANELSSide Panels1. Remove screws from bottom of pa

C24EO SERIES STEAMERS - REMOVAL AND REPLACEMENT OF PARTS2. Disconnect lead wires to component beingreplaced.3. Remove component.4. Reverse procedure t

C24EO SERIES STEAMERS - REMOVAL AND REPLACEMENT OF PARTSHIGH LIMIT THERMOSTAT Do not sharply bend and kink, or clampdown on the capillary tube or dama

C24EO SERIES STEAMERS - REMOVAL AND REPLACEMENT OF PARTSC. Install thermostat hand tight. Do not overtighten.TEMPERATURE PROBE1. Remove right SIDE PA

C24EO SERIES STEAMERS - REMOVAL AND REPLACEMENT OF PARTS5. Partially remove heating element assembly bypulling assembly towards you.6. Remove high lim